Synthesis and investigation of low band gap energy donor-acceptor polyaniline

Document Type : Original Research

Authors

1 Department of Organic Chemistry and Biochemistry Faculty of ChemistryUniversity of Tabriz29 Bahman Blvd.TabrizIran

2 University of Tabriz, Faculty of Chemistry

Abstract
Research subject: Solar cells has gained a great attention as a green, renewable and cheap energy resources. To overcome the challenging technical problems and improve their competitiveness with silicone solar cells, the design, synthesis and development of new materials with engineered band gap energies has found an undeniable importance.

Research approach: Herein, the synthesis of a polymer with donor-acceptor structure based on polyaniline grafted to ZnO nanoparticles at one end and naphthalene moiety at the other end of chains, and investigation of their chemical structure, composition, morphology, optical and electrochemical properties is reported. The chemical structure of the materials were analyzed by FT-IR and 1H NMR spectroscopy. The organic and inorganic contents of materials were determined by thermal gravimetric analysis (TGA) and atomic absorption spectroscopy (AAS) techniques. The morphology and size of nanoparticles were observed by scanning electron microscopy (SEM). The optical and electrical band gap energy of the samples were measured by ultraviolet visible-diffuse reflectance (UV-Vis-DRS) spectroscopy and cyclic voltammetry (CV) diagrams.

Main results: The chemical structure of designed materials has been successfully confirmed by the results of FT-IR and 1H NMR spectra. TGA and AAS analysis have indicated that the synthesized final material has contained about 10% of ZnO and 90% of organic parts including toluene-2,4-diisocyanate, 2,4-diaminotoluene, polyaniline and naphthalene groups. An almost highly uniform spherical nanoparticles with sizes about 70 nm has been observed by SEM images. UV-Vis-DRS spectroscopy and CV diagrams have revealed that by grafting ZnO nanoparticles and naphthalene moiety to the polyaniline chain ends, the optical and electrical band gap energy of the sample were lowered to 1.19 and 0.95 eV, respectively. It was concluded that the grafted groups to chain ends has increased the length of conjugated system, lowering the energy level of lowest unoccupied molecular orbital (LUMO) and increasing the energy level of highest occupied molecular orbital (HOMO). Detailed analysis of CV diagrams has indicated that the effect in lowering of LUMO has been a bit more pronounced than the increasing of HOMO energy level.

Keywords

Subjects


[1] Meng L., Zhang Y., Wan X., Li C., Zhang X., Wang Y., Ke X. and Xiao Z., Organic and Solution-Processed Tandem Solar Cells With 17.3% Efficiency, Science, 361, 1094-1098, 2018.
[2] Bura T., Blaskovits J.T. and Leclerc M., Direct (Hetero)Arylation Polymerization: Trends and Perspectives, Journal of the American Chemical Society, 138, 32, 10056–10071, 2016.
[3] Huang Y., Elder D.L., Kwiram A.L., Jenekhe S. A., Jen A.K.Y., Dalton L.R., and Luscombe C.K., Organic Semiconductors at the University of Washington: Advancements in Materials Design and Synthesis and Toward Industrial Scale Production, Advanced Materials, 33(22), 1904239, 2021. https://doi.org/10.1002/adma.201904239
[4] Roncali J. and Grosu I., The Dawn of Single Material Organic Solar Cells, Advanced Materials, 6(1), 1801026, 2019. https://doi.org/10.1002/advs.201801026
[5] Luo Z., Sun R., Zhong C., Liu T., Zhang G., Zou Y., Jiao X., Min J. and Yang C., Altering Alkyl-Chains Branching Positions for Boosting the Performance of Small-Molecule Acceptors for Highly Efficient Nonfullerene Organic Solar Cells, Science China Chemistry, 63, 361–369, 2020.
[6] Jiang Y., Chen J., Sun Y., Li Q., Cai Z., Li J., Guo Y., Hu W. and Liu Y., Fast Deposition of Aligning Edge‐On Polymers for High‐Mobility Ambipolar Transistors, Advanced Materials, 31(2), 1805761, 2019. https://doi.org/10.1002/adma.201805761.
[7] Kim M., Ryu S.U., Park S.A., Choi K., Kim T., Chung D. and Park T., Donor–Acceptor-Conjugated Polymer for High-Performance Organic Field-Effect Transistors: A Progress Report, Advanced Functional Materials, 30(20),1904545, 2019.
[8] Lee Y.H., Kweon O.Y., Kim H., Yoo J.H., Han S.G. and Oh J.H., Recent Advances in Organic Sensors for Health Self-Monitoring Systems, Journal of Materials Chemistry C, 6(32), 8569-8612, 2018.
[9] Facchetti, A., Polymer donor–polymer acceptor (all-polymer) solar cells, Materials Today, 16(4), 123-132, 2013. https://doi.org/10.1016/j.mattod.2013.04.005.
[10] Benten H., Mori D., Ohkita H., Ito S., Recent research progress of polymer donor/polymer acceptor blend solar cells, Journal of Materials Chemistry A, ,4(15), 5340-5365, 2016. https://doi.org/10.1039/C5TA10759H
[11] Ruvini S. Kularatne, Harsha D. Magurudeniya, Prakash Sista, Michael C. Biewer, Mihaela C. Stefan, Donor–Acceptor Semiconducting Polymers for Organic Solar Cells, Journal of Polymer Science, Part A: Polymer Chemistry, 51(4), 743–768, 2013. https://doi.org/10.1002/pola.26425
[12] Duan L. and Uddin A., Progress in Stability of Organic Solar Cells, Advanced Science, 7(11), 1903259, 2020. DOI: 10.1002/advs.201903259
[13] Najjar R. and Nematdoust S., A Resistive-Type Humidity Sensor Based on Polypyrrole and ZnO Nanoparticles: Hybrid Polymers vis-a-vis Nanocomposites, RSC Advances, 6 (113), 112129-112139, 2016.
[14] Dong X., Tian H., Xie Z., Geng Y. and Wang F., Donor-Acceptor Conjugated Polymers Based on Two-Dimensional Thiophene Derivatives for Bulk Heterojunction Solar Cells, Polymer Chemistry, 8, 421-430, 2017.
[15] Hosseini M.G., Jafari M. and Najjar R, Effect of Polyaniline–Montmorillonite Nanocomposite Powders Addition on Corrosion Performance of Epoxy Coatings on Al 5000, Surface and Coatings Technology, 206 (2-3), 280-286, 2011.
[16] Hosseini M.G., Bagheri R. and Najjar R., Electropolymerization of Polypyrrole and Polypyrrole‐ZnO Nanocomposites on Mild Steel and its Corrosion Protection Performance, Journal of Applied Polymer Science, 121 (6), 3159-3166, 2011.
[17] Hosseini M.G., Shahryari E., Najjar R. and Ahadzadeh I., Study of Super Capacitive Behavior of Polyaniline/Manganese Oxide-Carbon Black Nanocomposites Based Electrodes, International Journal of Nanoscience and Nanotechnology, 11 (3), 147-157, 2015.
[18] Armin A., Li W., Sandberg O. J., Xiao Z., Ding L., Nelson J., Neher D., Vandewal K., Shoaee S., Wang T., Ade H., Heumüller T., Brabec C, and Meredith P., A History and Perspective of Non-Fullerene Electron Acceptors for Organic Solar Cells, Advanced Energy Materials, 11(15), 20003570, 2021. https://doi.org/10.1002/aenm.202003570.
[19] Mohapatra A. A., Tiwari V. and Patil S., Energy Transfer in Ternary Blend Organic Solar Cells: Recent Insights and Future Directions, Energy & Environmental Science, 14(1), 302-319, 2021, DOI: 10.1039/D0EE03170D
[20] Li G., Xie Z., Wang Q., Chen X., Zhang Y. and Wang X., Asymmetric Acceptor-Donor-Acceptor Polymers with Fast Charge Carrier Transfer for Solar Hydrogen Production, Chemistry - A European Journal 27(3), 939-943, 2021. doi: 10.1002/chem.202003856
[21] Yue, S., Zhang and Lu. J., Controlled Growth of Well-Aligend Heirerchical ZnO Arrays by a Wet Chemical Method, Materials Letters, 63, 2149-2152, 2009.
[22] Yun, T.K., Park, S.S., Kim, D., Hwang, Y.K., Huh, S., Bae, J.Y. and Won, Y.S., Pore-Size Effect on Photovoltaic Performance of Dye-Sensitized Solar Cells Composed of Mesoporous Anatase-Titania, Journal of Power Sources, 196, 3678–3682, 2011.
[23] Radu A., Iftimie S., Ghenescu V., Besleaga C., Antohe V.A., Bratina G., Ion L., Craciun S., Girtan M. and Antohe S., LiF Layer and ZnO Nanoparticles Addings on the Performances of Flexible Photovoltaic Cells Based on Polymer Blends, Digest Journal of Nanomaterials and Biostructures, 6(3), 1141-1148, 2011.
[24] Pirotte G., Kesters J., Cardeynaels T., Verstappen P., D’Haen J., Lutsen L., Champagne B., Vanderzande D. and Maes W., The Impact of Acceptor–Acceptor Homocoupling on the Optoelectronic Properties and Photovoltaic Performance of PDTSQxff Low Bandgap Polymers, Macromolecular Rapid Communications, 39(14), 1800086, 2018. https://doi.org/10.1002/marc.201800086.
[25] Armarego W.L.F., Purification of Laboratory Chemicals, Eighth Ed., Elsevier Inc., 2017. (page 138, Diethyl ether, page 427 Toluene and page 539 THF).
[26] Vogel A.I., Tatchell A.R., Furnis B.S., Hannaford A.J., Smith P.W.G., Vogel's Textbook of Practical Organic Chemistry (5th Edition), Longman Scientific and Technical, John Wiley & Sons Inc. NY, USA, 1996. Page 879.
[27] Najjar R., Katourani S.A. and Hosseini M.G., Self-Healing and Corrosion Protection Performance of Organic Polysulfide@urea-Formaldehyde Resin Core-Shell Nanoparticles in Epoxy/PANI/ZnO Nanocomposite Coatings on Anodized Aluminum Alloy, Progress in Organic Coatings, 124 110–121, 2018.
[28] Najjar R., Akbari M., Mirmohseni A., Hosseini M., Preparation and corrosion performance of healable waterborne polyurethane coatings containing isophoronediisocyanate loaded silica capsules, Journal of the Taiwan Institute of Chemical Engineers, 93, 1–10, 2018, https://doi.org/10.1016/j.jtice.2018.05.021
[29] Hosseini M.G., Zeynali S., Momeni M.M. and Najjar R., Polyaniline Nanofibers Supported on Titanium as Templates for Immobilization of Pd Nanoparticles: A New Electro‐Catalyst for Hydrazine Oxidation, Journal of Applied Polymer Science 124(6), 4671-4677, 2012.
[30] Benoit D. N., Zhu H., Lilierose M. H., Verm R. A., Ali N., Morrison A. N., Fortner J. D., Avendano C., Colvin V. L., Measuring the Grafting Density of Nanoparticles in Solution by Analytical Ultracentrifugation and Total Organic Carbon Analysis, Analytical Chemistry 84(21), 9238-9245, 2012, DOI: 10.1021/ac301980a
[31] Bredas J.-L., Mind the Gap, Materials Horizones, 1, 17, 2014.
[32] Li Q., Yuan Y., Chen Z., Jin X., Wei T.-H., Li Y., Qin Y. and Sun W., Core−Shell Nanophosphor Architecture: Toward Efficient Energy Transport in Inorganic/Organic Hybrid Solar Cells, ACS Applied Materials and Interfaces, 6, 12798−12807, 2014.
[33] Makuła P., Pacia M. and Macyk W., How To Correctly Determine the Band Gap Energy of Modified Semiconductor Photocatalysts Based on UV−Vis Spectra, Journal of Physical Chemistry Letters, 9, 6814−6817, 2018.
[34] Md. Dilwar Alam Khan, Arshia Akhtar, Syed Ashfaq Nabi, Investigation of the electrical conductivity and optical property of polyaniline-based nanocomposite and its application as an ethanol vapor sensor, New Journal of Chemistry, 39 (5), 3728-3735, 2015. DOI: 10.1039/c4nj02260b
[35] Najafi-Ashtiani H. and Bahari A., Optical and Cyclic Voltammetry Behavior Studies on Nanocomposite Film of Copolymer and WO3 Grown by Electropolymerization, Synthetic Metals, 217, 19–28, 2016.
[36] Pan L., Hu B., Zhu X., Chen X., Shang J., Tan H., Xue W., Zhu Y., Liu G. and Li R.-W., Role of Oxadiazole Moiety in Different D–A Polyazothines and Related Resistive Switching Properties, Journal of Materials Chemistry C, 1(30), 4556-4564, 2013. https://doi.org/10.1039/C3TC30826J
[37] Huang, W. S., MacDiarmid A. G., Optical properties of polyaniline, Polymer, 34(9), 1833-1845, 1993.
[38] Almasi M.J., Fanaei Sheikholeslami T., Naghdi M.R. Band gap study of polyaniline and polyaniline/MWNT nanocomposites with in situ polymerization method, Composites Part B, 96, 63-68, 2016. http://dx.doi.org/10.1016/j.compositesb.2016.04.032
[39] Brown-Altvater F., Antonius G., Rangel T., Giantomassi M., Draxl C., Gonze X., Louie S. G., Neaton J. B., Band gap renormalization, carrier mobilities, and the electron-phonon self-energy in crystalline naphthalene, Physical Review B 101, 165102, 2020. DOI: 10.1103/PhysRevB.101.165102
[40] Cardona C.M., Li W., Kaifer A.E., Stockdale D. and Bazan G.C., Electrochemical Considerations for Determining Absolute Frontier Orbital Energy Levels of Conjugated Polymers for Solar Cell Applications, Advanced Materials, 23, 2367–2371, 2011.
[41] Leonat L., Sbârcea G. and Brânzoi I.V., Cyclic Voltammetry for Energy Levels Estimation of Organic Materials, U.P.B. Science Bulletin, Series B, 75 (3), 111-118, 2013.
[42] Sharma D., Singh Th., A DFT study of polyaniline/ZnO nanocomposite as a photocatalyst for the reduction of methylene blue dye, Journal of Molecular Liquids 293, 111528, 2019. https://doi.org/10.1016/j.molliq.2019.111528
[43] Zenasni M., Quintero-Jaime A., Benyoucef A., Benghalem A., Synthesis and characterization of polymer/V2O5 composites based on poly(2-aminodiphenylamine), Polymer Composites, 42(3), 1064-1074 , 2021. https://doi.org/10.1002/pc.25909
[44] Bekhti M. A., Belardja M. S., Lafjah M., Chouli F., Benyoucef A., Enhanced tailored of thermal stability, optical and electrochemical properties of PANI matrix containing Al2O3 hybrid materials synthesized through in situ polymerization, Polymer Composites, 42(xx), 6-14, 2021. https://doi.org/10.1002/pc.25812
[45] Cabuk M., Gündüz B., Controlling the optical properties of polyaniline doped by boric acid particles by changing their doping agent and initiator concentration, Applied Surface Science, 424 (Part 3), 345-351, 2017, http://dx.doi.org/10.1016/j.apsusc.2017.03.010
[46] Ashokkumar S.P., Vijeth H., Yesappa L., Niranjana M., Vandana M., Devendrappa H., Electrochemically synthesized polyaniline/copper oxide nano composites: To study optical band gap and electrochemical performance for energy storage devices, Inorganic Chemistry Communications 115, 107865, 2020, https://doi.org/10.1016/j.inoche.2020.107865
[47] Kouidri F.Z., Berenguer R., Benyoucef A., Morallon E., Tailoring the properties of polyanilines/SiC nanocomposites by engineering monomer and chain substituents, Journal of Molecular Structure, 1188, 121-128, 2019. https://doi.org/10.1016/j.molstruc.2019.03.100
[48] Usman F., Dennis J. O., Seong K. Ch., Ahmed A. Y., Meriaudeau F., Ayodele O. B., Tobi A. R., Rabih A. A. S., Yar A., Synthesis and characterisation of a ternary composite of polyaniline,reduced graphene-oxide and chitosan with reduced optical band gap andstable aqueous dispersibility, Results in Physics 15, 102690, 2019. https://doi.org/10.1016/j.rinp.2019.102690
[49] Belardja M.S., Djelad H., Lafjah M., Chouli F., Benyoucef A., The influence of the addition of tungsten trioxide nanoparticle size on structure, thermal, and electroactivity properties of hybrid material–reinforced PANI, Colloid and Polymer Science, 298, 1455–1463, 2020. https://doi.org/10.1007/s00396-020-04720-6